辛氧基苯基取代的吡啶并[3,4-b]吡嗪染料的合成与光伏性能研究

doi:10.6023/A14090642

摘要/Abstract

为了进一步提高电池的开路电压, 把吡啶并吡嗪核上的甲氧基苯换成辛氧基苯, 设计合成了一系列以三苯胺为给体、辛氧基苯取代的吡啶并[3,4-b]吡嗪为辅助受体、噻吩(呋喃、苯)为π-链、氰基乙酸为受体的新型染料敏化剂(OPP-I～Ⅲ). 对OPP-I～Ⅲ的光电化学性质、器件性能以及电荷转移动力学等进行了系统的测试及研究. 实验结果表明, 用辛氧基取代甲氧基, 能有效减少染料在TiO₂表面的聚集, 同时能阻止电解质和TiO₂导带的接触, 抑制电荷复合, 提高了开路电压. 最后, 在AM 1.5(100 mW·cm^-2)光强条件下, OPP-I敏化的电池最大光电转换效率为 6.57%(短路电流为 11.7 mA·cm^-2, 开路电压为 717 mV, 填充因子为 0.78).

关键词: 吡啶并[3,4-b]吡嗪, 辛氧基苯, 染料, 染料敏化太阳电池

Dye-sensitized solar cell (DSSC) is one of the promising technologies for the alternative to traditional silicon- based solar cells due to its ecological and economical fabrication processes. As one of the key components of a DSSC, the sensitizers have been demonstrated to be extremely important in determining the photoelectric conversion efficiency and device stability of DSSCs. In our previous study, a series of new pyrido[3,4-b]pyrazine-based organic sensitizers (PP-I and APP-I～IV) containing different donors and π-bridges have been synthesized and employed successfully in DSSCs. However, despite their remarkable stability, all of the devices exhibited quite low open-circuit voltages (V_ocs), which is adverse to the solar-to-electric power conversion efficiency (η). Therefore, to address this, we have replaced the 2,3-bis(4-methoxyphenyl)pyrido[3,4-b]pyrazine (APP) with 2,3-bis-(4-(octyloxy)phenyl)pyrido[3,4-b]pyrazine (OPP). As a result, a series of new sensitizers (OPP-I～Ⅲ) has been designed and synthesized with triphenylamine as the electron donor, OPP as the auxiliary acceptor, thiophene, furan and benzene as the π-linker, and cyanoacrylic acid as the acceptor moiety. Their optical and electrochemical properties, device performance and charge transfer kinetics were measured and studied. Compared with APP-Ⅲ, which has the highest V_oc in the previous work, the V_ocs of DSSCs based on OPP-I and OPP-Ⅲ have indeed been improved. Results showed that the replacement of the methoxy group with an octyloxy group can effectively reduce the π-π aggregation of the dyes on TiO₂ films. Moreover, the steric hindrance of the octyloxy group successfully suppressed charge recombination and improved the open-circuit voltage. DSSCs based on OPP-Ⅲ with benzene as the π-linker have higher V_oc than that of its counterparts with thiophene and furan as the π-linker, which might be ascribed to the bigger dihedral angle between benzene and OPP unit. In the end, DSSCs based on OPP-I showed the best conversion efficiency of 6.57% (J_sc=11.70 mA·cm^-2, V_oc=717 mV, ff=0.78) under standard global AM 1.5 solar light condition.

Key words: pyrido[3,4-b]pyrazine, octyloxybenzene, sensitizers, dye-sensitized solar cells

引用此文

张晓瑜, 应伟江, 武文俊, 李晶, 花建丽. 辛氧基苯基取代的吡啶并[3,4-b]吡嗪染料的合成与光伏性能研究[J]. 化学学报, 2015, 73(3): 272-280.

Zhang Xiaoyu, Ying Weijiang, Wu Wenjun, Li Jing, Hua Jianli. Synthesis and Photovoltaic Performance of (Octyloxyphenyl)pyrido-[3,4-b]pyrazine-based Sensitizers for Dye-sensitized Solar Cells[J]. Acta Chim. Sinica, 2015, 73(3): 272-280.

导出引用 EndNote|Reference Manager|ProCite|BibTeX|RefWorks

分享此文

参考文献

[1] O'Regan, B.; Grätzel, M. Nature 1991, 353, 737.
[2] Hagfeldt, A.; Boschloo, G.; Sun, L. C.; Kloo, L.; Pettersson, H. Chem. Rev. 2010, 110, 6595.
[3] He, J. J.; Chen, S. X.; Wang, T. T.; Zeng, H. P. Chin. J. Org. Chem. 2012, 32, 472. (何俊杰, 陈舒欣, 王婷婷, 曾和平, 有机化学, 2012, 32, 472).
[4] Feng, X. M.; Huang, X. W.; Huang, H.; Shen, P.; Zhao, B.; Tan, S. T. Acta Chim. Sinica 2010, 68, 1123. (冯小明, 黄先威, 黄辉, 沈平, 赵斌, 谭松庭, 化学学报, 2010, 68, 1123).
[5] Feng, X. M.; Huang X. W.; Tan, Z.; Zhao, B.; Tan, S. T. Acta Chim. Sinica 2011, 69, 653. (冯小明, 黄先威, 谭卓, 赵斌, 谭松庭, 化学学报, 2011, 69, 653.)
[6] Kou, D. X.; Liu, W. Q.; Hu, L. H.; Chen, S. H.; Huang, Y.; Dai, S. Y. Acta Chim. Sinica 2013, 71, 1149. (寇东星, 刘伟庆, 胡林华, 陈双宏, 黄阳, 戴松元, 化学学报, 2013, 71, 1149.)
[7] Kou, D. X.; Liu, W. Q.; Hu, L. H.; Chen, S. H.; Huang, Y.; Dai, S. Y. Acta Chim. Sinica 2013, 71, 777. (寇东星, 刘伟庆, 胡林华, 陈双宏, 黄阳, 戴松元, 化学学报, 2013, 71, 777.)
[8] Tang, X.; Wang, Y. X. Acta Chim. Sinica 2013, 71, 193. (唐笑, 汪禹汛, 化学学报, 2013, 71, 193).
[9] Liang, M.; Tao, Z. L.; Chen, J. Chemistry Online 2005, 68, 889. (梁茂, 陶占良, 陈军, 化学通报, 2005, 68, 889.)
[10] Han, L.; Zhou, X.; Ye, Q.; Li, Y. J.; Gao, J. R. Chin. J. Org. Chem. 2013, 33, 1000. (韩亮, 周雪, 叶青, 李郁锦, 高建荣, 有机化学, 2013, 33, 1000.)
[11] Wang, Z. Y.; Wang, R. Y.; Fu, N. Y. Chin. J. Org. Chem. 2011, 31, 415. (王振宇, 王如勇, 傅南雁, 有机化学, 2011, 31, 415.)
[12] Liang, M.; Xu, Y. J. ; Wang, X. D.; Liu, X. J.; Sun, Z.; Xue, S. Acta Chim. Sinica 2011, 69, 2092. (梁茂, 徐英军, 王旭达, 刘秀杰, 孙喆, 薛松, 化学学报, 2011, 69, 2092.)
[13] Komiya, R.; Fukui, A.; Murofushi, N.; Koide, N.; Yamanaka, R.; Katayama, H. In 21st International Photovoltaic Science and Engineering Conference, Fukuoka, November, 2011.
[14] Yella, A.; Lee, H.-W.; Tsao, H. N.; Yi, C. Y.; Chandiran, A. K.; Nazeeruddin, M. K.; Diau, E. W.-G.; Yeh, C.-Y.; Zakeeruddin, S. M.; Grätzel, M. Science 2011, 334, 629.
[15] Mathew, S.; Yella, A.; Gao, P.; Humphry-Baker, R.; Curchod, B. F. E.; Ashari-Astani, N.; Tavernelli, I.; Rothlisberger, U.; Nazeeruddin, M. K.; Grätzel, M. Nat. Chem. 2014, 6, 242.
[16] Yang, J. B.; Ganesan, P.; Teuscher, J.; Moehl, T.; Kim, Y. J.; Yi, C. Y.; Comte, P.; Pei, K.; Holcombe, T. W.; Nazeeruddin, M. K.; Hua, J.; Zakeeruddin, S. M.; Tian, H.; Grätzel, M. J. Am. Chem. Soc. 2014, 136, 5722.
[17] Liang, M.; Chen, J. Chem. Soc. Rev. 2013, 42, 3453.
[18] Qu, S. Y.; Hua, J. L.; He, T. Sci. China Chem. 2012, 55, 677.
[19] Hao, Y.; Yang, X. C.; Zhou, M. Z.; Cong, J. Y.; Wang, X. N.; Hagfeldt, A.; Sun, L. C. ChemSusChem 2011, 4, 1601.
[20] Haid, S.; Marszalek, M.; Mishra, A.; Wielopolski, M.; Teuscher, J.; Moser, J.-E.; Humphry-Baker, R.; Zakeeruddin, S. M.; Grätzel, M.; Bäuerle, P. Adv. Funct. Mater. 2012, 22, 1291.
[21] Cai, N.; Wang, Y. L.; Xu, M. F.; Fan, Y.; Li, R. Z.; Zhang, M.; Wang, P. Adv. Funct. Mater. 2013, 23, 1846.
[22] Velusamy, M.; Justin Thomas, K. R.; Lin, J. T.; Hsu, Y. C.; Ho, K. C. Org. Lett. 2005, 7, 1899.
[23] Kim, J. J.; Choi, H.; Lee, J. W.; Kang, M. S.; Song, K.; Kang, S. O.; Ko, J. J. Mater. Chem. 2008, 18, 5223.
[24] Tang, Z. M.; Lei, T.; Jiang, K. J.; Song, Y. L.; Pei, J. Chem.-Asian J. 2010, 5, 1911.
[25] Haid, S.; Marszalek, M.; Mishra, A.; Wielopolski, M.; Teuscher, J.; Moser, J. E.; Bäuerle, P. Adv. Funct. Mater. 2012, 22, 1291.
[26] Liu, B.; Liu, Q.; You, D.; Li, X.; Naruta, Y.; Zhu, W. H. J. Mater. Chem. 2012, 22, 13348.
[27] Zhu, W. H.; Wu, Y. Z.; Wang, S. T.; Li, W. Q.; Li, X.; Chen, J.; Wang, Z. S.; Tian, H. Adv. Funct. Mater. 2011, 21, 756.
[28] Wu, Y. Z.; Zhang, X.; Li, W. Q.; Wang, Z. S.; Tian, H.; Zhu, W. H. Adv. Energy Mater. 2012, 2, 149.
[29] Wu, Y. Z.; Marszalek, M.; Zakeeruddin, S. M.; Zhang, Q.; Tian, H.; Grätzel, M.; Zhu, W. H. Energy Environ. Sci. 2012, 5, 8261.
[30] Cao, Z. C.; He, Z.; Deng, L. J.; Tan, S. T. Chin. J. Org. Chem. 2014, 34, 340. (曹镇财, 何舟, 邓利军, 谭松庭, 有机化学, 2014, 34, 340.)
[31] He, P.; Li, Z. F.; Hou, Q. F.; Wang, Y. L. Chin. J. Org. Chem. 2013, 33, 288. (和平, 李在房, 侯秋飞, 王艳玲, 有机化学, 2013, 33, 288.)
[32] Cui, Y.; Wu, Y. Z.; Lu, X. F.; Zhang, X.; Zhou, G.; Miapeh, F. B.; Zhu, W. H.; Wang, Z. S. Chem. Mater. 2011, 23, 4394.
[33] Mao, J. Y.; Guo, F. L.; Ying, W. Y.; Wu, W. J.; Li, J.; Hua, J. L. Chem.-Asian J. 2012, 7, 982.
[34] Chang, D. W.; Lee, H. J.; Kim, J. H.; Park, S. Y.; Park, S. M.; Dai, L.; Baek, J. B. Org. Lett. 2011, 13, 3880.
[35] Lu, X. F.; Feng, Q. Y.; Lan, T.; Zhou, G.; Wang, Z. S. Chem. Mater. 2012, 24, 3179.
[36] Shi, J.; Chen, J. N.; Chai, Z. F.; Wang, H.; Tang, R. L.; Fan, K.; Wu, M.; Han, H. W.; Qin, J. G.; Peng, T. Y.; Li, Q. Q.; Li, Z. J. Mater. Chem. 2012, 22, 18830.
[37] Li, W. Q.; Wu, Y. Z.; Zhang, Q.; Tian, H.; Zhu, W. H. ACS Appl. Mater. Interfaces 2012, 4, 1822.
[38] Qu, S. Y.; Wu, W. J.; Hua, J. L.; Kong, C.; Long, Y. T.; Tian, H. J. Phys. Chem. C 2010, 114, 1343.
[39] Qu, S. Y.; Wang, B.; Guo, F. L.; Li, J.; Wu, W. J.; Kong, C.; Long, Y. T.; Hua, J. Dyes Pigm. 2012, 92, 1384.
[40] Qu, S. Y.; Qin, C.; Islam, A.; Wu, Y. Z.; Zhu, W. H.; Hua, J. L.; Tian, H.; Han, L. Y. Chem. Commun. 2012, 48, 6972.
[41] Wu, Y. Z.; Zhu, W. H. Chem. Soc. Rev. 2013, 42, 2039.
[42] Lee, B.; Yamamoto, T. Macromolecules 1999, 32, 1375.
[43] DuBois, C.; Reynolds, J. Adv. Mater. 2002, 14, 1844.
[44] Jonforsen, M.; Johansson, T.; Inganäs, O.; Andersson, M. Macromolecules 2002, 35, 1638.
[45] Jonforsen, M.; Johansson, T.; Spjuth, L.; Inganäs, O.; Andersson, M. Synth. Met. 2002, 131, 53.
[46] Thompson, B.; Madrigal, L.; Pinto, M.; Kang, T.; Schanze, K.; Reynolds, J. J. Polym. Sci. Part A: Polym. Chem. 2005, 43, 1417.
[47] Wu, P. T.; Kim, F.; Champion, R.; Jenekhe, S. Macromolecules 2008, 41, 7021.
[48] Wu, P. T.; Bull, T.; Kim, F.; Luscombe, C.; Jenekhe, S. Macromolecules 2009, 42, 671.
[49] Huang, X. B.; Shi, Q. Q.; Chen, W. Q.; Zhu, C. L.; Zhou, W. Y.; Zhao, Z.; Duan, X. M.; Zhan, X. W. Macromolecules 2010, 43, 9620.
[50] Shi, Q. Q.; Chen, W. Q.; Xiang, J. F.; Duan, X. M.; Zhan, X. W. Macromolecules 2011, 44, 3759.
[51] Blouin, N.; Michaud, A.; Gendron, D.; Wakim, S.; Blair, E.; Neagu-Plesu, R.; Belletete, M.; Durocher, G.; Tao, Y.; Leclerc, M. J. Am. Chem. Soc. 2008, 130, 732.
[52] Zhang, Q.; Norton, J.; Wu, P.; Barlow, S.; Jenekhe, S.; Kippelen, B.; Bredasa, J.; Marder, S. J. Mater. Chem. 2011, 21, 4971.
[53] Henriksson, P.; Muller, C.; Bergqvist, J.; Hadipour, A.; Heremans, P.; Andersson, M. Sol. Energy Mater. Sol. Cells 2012, 105, 280.
[54] Ying, W. J.; Yang, J. B.; Wielopolski, M.; Moehl, T.; Moser, J.-E.; Comte, P.; Hua, J. L.; Zakeeruddin, S. M.; Tian, H.; Grätzel, M. Chem. Sci. 2014, 5, 206.
[55] Pei, K.; Wu, Y. Z.; Wu, W. J.; Zhang, Q.; Chen, B.; Tian, H.; Zhu, W. H. Chem.-Eur. J. 2012, 18, 8190.
[56] Liu, D. S.; Ding, W. L.; Zhu, K. L.; Geng, Z. Y.; Wang D. M.; Zhao, X. L. Dyes Pigm. 2014, 105, 192.
[57] Pastore, M.; Mosconi, E.; Angelis, F. D. J. Phys. Chem. C 2012, 116, 5965.
[58] Planells, M.; Pellejà, L.; Clifford, J. N.; Pastore, M.; Angelis, F. D.; López, N.; Marder, S. R.; Palomares, E. Energy Environ. Sci. 2011, 4, 1820.
[59] Lim, J.; Kwon, Y. S.; Park, T. Chem. Commun. 2011, 47, 4147.
[60] Wang, Z.-S.; Koumura, N.; Cui, Y.; Takahashi, M.; Sekiguchi, H.; Mori, A.; Kubo, T.; Furube, A.; Hara, K. Chem. Mater. 2008, 20, 3993.
[61] Hara, K.; Sato, T.; Katoh, R.; Furube, A.; Ohga, Y.; Shinpo, A.; Suga, S.; Sayama, K.; Sugihara, H.; Arakawa, H. J. Phys. Chem. B 2003, 107, 597.
[62] Wenger, S.; Bouit, P. A.; Chen, Q.; Teuscher, J.; Censo, D.; Humphry-Baker, R.; Moser, J. E.; Delgado, J. L.; Martin, N.; Zakeeruddin, S. M.; Grätzel, M. J. Am. Chem. Soc. 2010, 132, 5164.