SIOC English
化学学报
高级检索

化学学报 ›› 2008, Vol. 66 ›› Issue (10): 1173-1180. 上一篇    下一篇

研究论文

镍氢电池的循环性能与活性物质微结构的研究

娄豫皖1，杨传铮*,1，何丹农2，夏保佳1   

  1. (1中国科学院上海微系统与信息技术研究所 上海 200050)
    (2纳米技术及应用国家工程研究中心 上海 200241)
  • 投稿日期:2007-06-22 修回日期:2008-12-17 发布日期:2008-05-28
  • 通讯作者: 杨传铮

Research of Circulation Properties and Microstructure in Active Substances for MH/Ni Battery

LOU, Yu-Wan1, YANG, Chuan-Zheng*,1, HE, Dan-Nong2, XIA, Bao-Jia1   

  1. (1 Shanghai Institute of Micro-system and Information Technology, Chinese Academy of Sciences, Shanghai 200050)
    (2 National Engineering Research Center for Nanotechnology, Shanghai 200241)
  • Received:2007-06-22 Revised:2008-12-17 Published:2008-05-28
  • Contact: YANG, Chuan-Zheng

PDF

686

被引次数

17 | 4

与循环试验大致同步, 用静态(初态和终态)或准动态(增加若干个中间态)的模式对MH/H电池循环性能、电极(包括负极和正极)材料的微结构进行了X射线衍射(XRD)研究, 发现循环性能衰减与正极材料β-Ni(OH)2的点阵参数、平均晶粒尺度、微应变和总的层错几率均随循环周期增加而减小以及负极材料中腐蚀产物A(OH)3和B相出现和增加有一定的对应关系, 发现MH/Ni 电池循环性能的衰减是正极材料和负极材料的结构和微结构随着循环次数的增加发生明显变化, 恶化了正负极材料的电化学性能, 同时消耗和恶化了电解液的综合结果. 为了提高电池的循环性能, 采用不同正极材料的添加剂. 结果表明, CaF2和Lu2O3有明显的效果, 其中CaF2效果最好, 并有广泛的实用性.

关键词: MH/H电池, 循环性能, 微结构, 正极添加剂, X射线衍射

The circulation properties and microstructure in active substances for MH/Ni batteries have been researched. It was found that corresponding relationship among attenuation of circulation property and decreasing of lattice parameters, average grain size, micro-strain, total fault probability in β-Ni(OH)2 with increasing of circulation cycles and producing and increasing of corrosive products (A(OH)3 and B phases) in AB5 with increasing of circulation cycles. Attenuation mechanics of circulation properties for MH/Ni battery has been discussed. Circulation properties attenuation is the synthesized results of obvious changes of crystal structure and microstructure in positive and negative electrode materials during circulation cycle experiment, especially corrosion products are separated out in AB5 materials, which deteriorating electrochemical properties of β-Ni(OH)2 and AB5 materials and which depleting and deteriorating electrolyte at the same times. For elevating circulation property of this battery some additives of positive electrode were used. The research results show that effects of CaF2 and Lu2O3 are better. Specially the effect of CaF2 is the best, so it has broad practicability.

Key words: MH/Ni battery, circulation properties, microstructure, positive electrode additives, X-ray diffraction