新型苯并噻唑离子液体的合成及其催化蓖麻油酸酯化研究

doi:10.6023/cjoc201511019

有机化学 ›› 2016, Vol. 36 ›› Issue (5): 1104-1110.DOI: 10.6023/cjoc201511019 上一篇下一篇

研究简报

新型苯并噻唑离子液体的合成及其催化蓖麻油酸酯化研究

张海飞, 刘冬梅, 康婷婷, 王也, 张小祥, 朱新宝

南京林业大学化学工程学院南京 210037

收稿日期:2015-11-12 修回日期:2015-12-21 发布日期:2016-01-15
通讯作者: 朱新宝 E-mail:s070038@hotmail.com,zhuxinbao@njfu.com.cn
基金资助:
国家林业局948项目基金(No.2015-4-55)资助项目.

Synthesis of Novel Benzothiazolium Ionic Liquids and Research on Their Catalytic Esterification for Ricinoleic Acid

Zhang Haifei, Liu Dongmei, Kang Tingting, Wang Ye, Zhang Xiaoxiang, Zhu Xinbao

College of Chemical Engineering, Nanjing Forestry University, Nanjing 210037

Received:2015-11-12 Revised:2015-12-21 Published:2016-01-15
Supported by:
Project supported by the 948 Project Foundation of State Forestry Administration (No. 2015-4-55).

文章分享

1. 新型苯并噻唑离子液体的合成及其催化蓖麻油酸酯化研究.PDF(1075KB)

摘要/Abstract

以价格低廉的苯并噻唑为原料,合成了4种新型功能化布朗斯特酸性离子液体:苯并噻唑硫酸氢盐([HBth]-HSO₄)、苯并噻唑磷酸二氢盐([HBth]H₂PO₄)、苯并噻唑高氯酸盐([HBth]ClO₄)、苯并噻唑硝酸盐([HBth]NO₃),其结构经FT-IR、HRMS、NMR表征得到确认.考察了4种酸性离子液体在蓖麻油酸和乙二醇丁醚(EGBE)酯化反应中的催化活性,并与以浓硫酸为催化剂的催化体系相对照.结果表明:当n(蓖麻油酸):n(乙二醇丁醚)=1:1.15,离子液体催化剂用量为蓖麻油酸重量的2%,反应温度90℃,反应时间5h,酯化率可达98.8%,离子液体催化剂经真空干燥重复使用10次后,仍具有较高的催化活性.还考察了以苯并噻唑硫酸氢盐为催化剂催化合成系列蓖麻油酸二元醇醚酯和短链脂肪酸酯,也获得了较高的酯化率,且离子液体均能与酯产物自动分相.与传统硫酸催化酯化相比,此类离子液体催化酯化具有生产成本低、过程清洁、使用周期长等优点,完全可以替代传统浓硫酸催化蓖麻油酸酯化反应.

关键词: 苯并噻唑, 离子液体, 蓖麻油酸, 酯化反应, 催化活性

Four new task-specfic benzothiazolium ionic liquids (ILs) [HBth]HSO_4, [HBth]H₂PO₄, [HBth]ClO₄, [HBth]NO₃ were synthesized and characterized by NMR and FT-IR, which bear the proton acid groups based on low price benzothiazole as raw material. The catalytic activities of these acidic ionic liquids were investigated by the esterification of ricinoleic acid with ethanol ethylene glycol monobutyl ether (EGBE) and were compared with concentrated sulfuric acid. The results showed that under the optimized conditions: n(Ricinoleic acid):n(EGBE)=1:1.15, catalyst dosage 2% (wt) of ricinoleic acid, reaction temperature 90 ℃ and reaction time 5 h, esterification yield was up to 98.8%. The ionic liquids dried in vacuum till remained high activity after reused for 10 times. Finally, the yields of series of ricinoleic acid binary alcohol ether ester and short-chain fatty acids ester were also high with [HBth]HSO₄ as catalyst, and the ionic liquids can form split-phases with ester product. Compared with the traditional sulfuric acid catalytic esterification, catalytic esterification of such ionic liquid has the advantages of low production cost, clean process, low corrosion rate, reusable, and has the potential of replacing the traditional sulfuric acid in catalytic esterification reaction of ricinoleic acid.

Key words: benzothiazolium, ionic liquids, ricinoleic acid, esterification, catalytic activity

引用此文

张海飞, 刘冬梅, 康婷婷, 王也, 张小祥, 朱新宝. 新型苯并噻唑离子液体的合成及其催化蓖麻油酸酯化研究[J]. 有机化学, 2016, 36(5): 1104-1110.

Zhang Haifei, Liu Dongmei, Kang Tingting, Wang Ye, Zhang Xiaoxiang, Zhu Xinbao. Synthesis of Novel Benzothiazolium Ionic Liquids and Research on Their Catalytic Esterification for Ricinoleic Acid[J]. Chin. J. Org. Chem., 2016, 36(5): 1104-1110.

导出引用 EndNote|Reference Manager|ProCite|BibTeX|RefWorks

分享此文

参考文献

[1] Zeng, Q.-F.; Dong, G.-N. Tribol. Lett. 2013, 52, 47.
[2] Tong, L.-G.; Rong, H.; Lin, S.-J. J. Beijing Inst. Petro-Chem. Technol. 2010, 18, 58 (in Chinese).
(佟拉嘎, 荣华, 林世静, 北京石油化工学院学报, 2010, 18, 58.)
[3] Doudin, K.; A-Malaika, S.; Dole, H. Polym. Degrad. Stab. 2011, 96, 438.
[4] Dias, J.-M.; Araujo, J.-M.; Costa, J.-F. Energy2013, 53, 58.
[5] Amador, P.; Martinez, E.; Sanchez-Daza, O. J. Chem. Thermodyn. 2012, 50, 15.
[6] Wu, J. Agric. Mach. 2011, 61, 61 (in Chinese).
(吴杰, 农业机械, 2011, 61, 61.)
[7] Zhao, D.-B.; Fei, Z.-F.; Geldbach, T.-J.; Scopelliti, R.; Laurenczy, G.; Dyson, P.-J. J. Am. Chem. Soc. 2005, 88, 665.
[8] Inui, K.; Kurabayashi, T.; Sato, S.; Ichikawa, N. J. Mol. Catal A: Chem. 2004, 216, 147.
[9] Amador, P.; Martinez E, Sanchez-Daza O. J. Chem. Thermodyn.2012, 50, 15.
[10] Li, Y.; Hu, S.-L.; Cheng, J.-H.; Lou, W.-Y. Chin. J. Catal. 2014, 35, 396.
[11] Zhao, D.-S.; Liu, M.-S.; Ge, J.-J.; Zhang, J.; Ren, P.-B. Chin. J. Org. Chem. 2012, 32, 2382 (in Chinese).
(赵地顺, 刘猛帅, 葛京京, 张娟, 任培兵, 有机化学, 2012, 32, 2382.)
[12] Hou, H. L.; Li, Z. F.; Ying, A. G. Chin. J. Org. Chem. 2014, 34, 1277 (in Chinese).
(侯海亮, 李志峰, 应安国, 许松林, 有机化学, 2014, 34, 1277.)
[13] Peter, W.; Wilhelm, K. Angew. Chem., Int. Ed. 2000, 39, 3772.
[14] Plechkova, N.-V.; Seddon, K.-R. Chem. Soc. Rev. 2008, 370, 123.
[15] Tokuda, H.; Tsuzuki, S.; Susan, M. A.-B. H.; Hayamizu, K.; Watanabe, M. J. Chin. Phys. Chem. B 2006, 110, 19593.
[16] Song, Y.-L.; Wang, X.-C.; Huang, C.-P.; Liang, F.-B.; Liu, Z.-C.; Chen, B.-H. Chin. J. Org. Chem. 2013, 33, 1715.
[17] Jankovic, M. R.; Sinadinovic-Fiser, S. V.; Govedarica, O.-M. Ind. Eng. Chem. Res.2014, 53, 9357.
[18] Elsheikh, Y.-A. Energy Convers. Manage.2011, 52, 804.
[19] Liu, S.-W.; Li, L.; Yu, S.-T. Chin. J. Catal. 2010, 31, 1433.
[20] Earle, M.-J.; Seddon, K.-R. Pure Appl. Chem. 2000, 72: 1391-1398.
[21] Marsh, K.-N; Boxall, J.-A.; Lichtenthaler, R. Fluid Phase Equilib.2004, 219: 93~98.
[22] Wu, K.; Li, C.-X. Chin. J. Org. Chem. 2011, 31, 119 (in Chinese).
(吴坤, 李存雄, 有机化学, 2011, 31, 119.)
[23] Li, J.-Y.; Peng, J.-J.; Qiu, H.-Y.; Jiang, J.-X.; Wu, J.-R.; Ni, Y.; Lai, G.-Q. Chin. J. Org. Chem. 2007, 27, 483 (in Chinese).
(厉嘉云, 彭家建, 邱化玉, 蒋剑雄, 邬继荣, 倪勇, 来国桥, 有机化学, 2007, 27, 483.)
[24] Wang, Y.-Y.; Wu, Y.-T.; Liu, K.; Dai, L.-Y. Chin. Chem. Lett. 2012, 23, 1031.
[25] Venkataraman, V-R; Ali, K.-S. Indian J. Heterocycl. Chem. 2001, 11, 93.
[26] Zhao, D. S.; Liu, M. S.; Xu, Z. C.; F, J. T.; Ren, P. B. Chem. Ind. Eng. Prog. 2011, 30, 2287 (in Chinese).
(赵地顺, 刘猛帅, 徐智策, 付江涛, 任培兵, 化工进展, 2011, 30, 2287.)
[27] Wasserscheid, P.; Keim, W. Angew. Chem., Int. Ed. 2000, 39, 3772.
[28] Huddleston, J. G.; Visser, A. E.; Reichert, W. M.; Willauer, H. D.; Broker, G. A.; Rogers, R. D. Green. Chem. 2001, 3, 156.
[29] Fredakle, C.-P.; Crosthwaite, J.-M.; Hert, D.-G. J. Chem. Eng. Data 2004, 49, 954.
[30] Yang, L.; Lu, J.; Bai, Y. J. Chin.. J. Org. Chem. 2003, 23, 659 (in Chinese).
(杨玲, 路军, 白银娟, 有机化学, 2003, 23, 659.)
[31] Anthony, J. L.; Maginn, E. J.; Brennecke, J.-F. J. Phys. Chem. B2001, 105, 10942.
[32] Ji, S. X.; Zhao, Y. J.; He, C. Petrochem. Technol. 2010, 39, 251 (in Chinese).
(纪世雄, 赵义军, 何春, 石油化工, 2010, 39, 251.)
[33] Wang, Q.; Ma, R. X. J. Langzhou Univ. Technol. 2005, 31, 57 (in Chinese).
(王俏, 马荣萱, 兰州理工大学学报, 2005, 31, 57.)
[34] Zeng, H. Y.; Ying, S. F.; Li, Y. Chin. J. Org. Chem. 2007, 27, 528 (in Chinese).
(曾鸿耀, 尹述凡, 李颖, 有机化学, 2007, 27, 528.)
[35] Peng, Q.; Zhang, Y. W.; Wang, X. M. Chin. J. Synth. Chem. 2012, 20, 28 (in Chinese).
(彭琦, 张义文, 王小敏, 王卓端, 姚舜, 宋航, 合成化学, 2012, 20, 28.)
[36] Huang, B.-H.; Li, Z.-J.; Shi, N.; Xu, X.-L.; Fang, Y.-X. Chin. J. Org. Chem. 2009, 29, 770 (in Chinese).
(黄宝华, 黎子进, 史娜, 徐效陵, 张焜, 方岩雄, 有机化学, 2009, 29, 770.)

新型苯并噻唑离子液体的合成及其催化蓖麻油酸酯化研究

Synthesis of Novel Benzothiazolium Ionic Liquids and Research on Their Catalytic Esterification for Ricinoleic Acid

PDF

补充材料

可视化

被引次数

摘要/Abstract

引用此文

分享此文

参考文献

相关文章 15

编辑推荐

相关统计

本文评价

[1]	钟赟哲, 陈颖, 俞磊, 周宏伟. 电化学介导羧酸与醇的酯化反应[J]. 有机化学, 2023, 43(8): 2855-2863.
[2]	石义军, 孙馨悦, 曹晗, 别福升, 马杰, 刘哲, 丛兴顺. 室温下酯与伯硫醇的硫酯化反应[J]. 有机化学, 2023, 43(7): 2499-2505.
[3]	张旭征, 于凤丽, 袁冰, 解从霞, 于世涛. 钒钼杂多酸盐相转移催化环戊烯氧化制备戊二醛[J]. 有机化学, 2023, 43(4): 1444-1451.
[4]	张越华, 聂飞, 周路, 王晓烽, 刘源, 霍延平, 陈文铖, 赵祖金. 苯并噻唑酮类热活化延迟荧光材料的合成及其光电性能研究[J]. 有机化学, 2023, 43(11): 3876-3887.
[5]	刘梦, 黄延茹, 孙小飞, 汤立军. 一种基于“聚集诱导发光+激发态分子内质子转移”机制的苯并噻唑衍生物荧光探针及其对次氯酸根的识别[J]. 有机化学, 2023, 43(1): 345-351.
[6]	徐勇, 张永兴, 胡佳, 陈宬, 原晔, Francis Verpoort. ZnO/离子液体体系催化常压二氧化碳合成β-羰基氨基甲酸酯[J]. 有机化学, 2022, 42(8): 2542-2550.
[7]	傅琴姣, 张瑞芹, 裘浣沂, 马仁超, 马永敏. Selectfluor氧化合成2-芳基苯并噻唑的新方法[J]. 有机化学, 2021, 41(9): 3585-3592.
[8]	王鹏, 杨妲, 刘欢. 1,3-二烯烃的羰基化反应研究进展[J]. 有机化学, 2021, 41(9): 3379-3389.
[9]	王卫伟, 赵宇, 刘鑫磊, 蒋家珍, 王明安. 3-芳基-7-甲基-7-羟基-2-辛烯-6-内酯类化合物的合成及杀菌活性[J]. 有机化学, 2021, 41(6): 2343-2353.
[10]	董宏波, 王卫伟, 赵宇, 刘鑫磊, 王明安. 3,7-二甲基-7-羟基-2-辛烯-6-内酯类似物的合成及杀菌活性[J]. 有机化学, 2021, 41(4): 1646-1657.
[11]	侯秋飞, 张锐, 梁洁媚, 姚维忠, 程华, 陈宬. 2-氨基苯并噻唑类化合物的合成研究进展[J]. 有机化学, 2021, 41(4): 1498-1526.
[12]	张俊, 刘雅菲, 张育榕, 呼亮, 韩世清. 2-取代苯并噻唑化合物的合成进展[J]. 有机化学, 2021, 41(3): 1053-1071.
[13]	程诗砚, 欧楚鸿, 林洪敏, 贾均松, 唐海涛, 潘英明, 黄国保, 蒙秀金. 电化学介导的芳香醛和脂肪醇氧化酯化反应[J]. 有机化学, 2021, 41(12): 4718-4724.
[14]	宁资慧, 彭欣华, 白瑞, 刘珊珊, 李卓, 焦林郁. 铱催化的苯甲酰胺和磷酰叠氮在离子液体中的C—H键胺化反应[J]. 有机化学, 2021, 41(11): 4484-4492.
[15]	张璐, 刘爱芹, 刘华铮, 万仁忠, 孙书涛, 刘磊. 基于化学和对映选择性转移氢化的β,γ-炔基α-氨基酸酯的催化不对称合成研究[J]. 有机化学, 2020, 40(9): 2904-2911.